网站地图
RSS订阅
匿名投稿
您的位置:网站首页 > 新闻中心

工业金刚砂耐磨地坪的优缺点

作者:地坪 来源:未知 日期:2017-8-5 13:19:42 人气: 标签:
导读:金刚砂耐磨地坪也称无机骨料耐磨地坪,耐磨地面,耐磨地坪,硬化地坪,硬化地面、硬质地坪、硬质地面。耐磨地坪材料是工厂预拌、现场即用的干撒式地面硬化剂。主

金刚砂耐磨地坪也称无机骨料耐磨地坪,耐磨地面,耐磨地坪,硬化地坪,硬化地面、硬质地坪、硬质地面。耐磨地坪材料是工厂预拌、现场即用的干撒式地面硬化剂。主要由高强度水泥、无机耐磨骨料、颜料粉(水泥原色无)、添加剂等组成。骨料为砂状,平均粒径1.5mm,约占总量60%;胶结物为经处理的高标号水泥,除采用水泥本色外,还有红、黄、绿、灰等多种色彩可供选择。硬化剂骨料成分为天然矿石。系不生锈的非金属性骨料,硬度在莫氏8度以上。除天然矿石骨料外,其他水泥、色料等重量不超过总重量的25%。

Emery wear-resisting floor also calls the mineral aggregate wear-resistant floors, wear-resisting floor, wear-resisting flooring, floor, hardening, hard floor on the ground, hard ground.Wear-resisting flooring material is factory ready-mixed, the scene of the box type curing agent on the ground.Mainly by high strength cement, abrasive aggregates, pigments inorganic powder (cement color), additives, etc.Sand aggregate to form, the average particle size of 1.5 mm, about 60% of the total;Cement for the treatment of high grade cement, besides using cement color, there is red, yellow, green, grey etc. Various colors to choose from.Hardener aggregate components in natural minerals.Is not rusty nonmetal aggregate, in mohs hardness above eight degrees.In addition to the natural mineral aggregate, cement and other pigment such as weight is less than 25% of the total weight.

本产品直接施工在初凝阶段的混凝土或水泥砂浆表面,经抹平后形成一层坚硬耐磨、无尘美观的硬化地板。主要有以下特点:

This product is directly constructed in the concrete or cement mortar surface of the initial stage, and then it has been flattened and formed a hard and durable, clean and beautiful hardening floor. Main features include:

优点:

Advantages:

1、颜色可选,表面密实、不易起尘,易清洁

1. The color can be chosen, the surface is dense, not easy to pick up dust, easy to clean

2、是传统工业地面水磨石的取代品。

2. It is the substitute of traditional industrial ground terrazzo.

3、与混凝土同步施工,能快速投入使用;

3. Synchronous construction with concrete can be put into use quickly;

4、成本低廉,性价比高。使用寿命长。

4. Low cost and high cost performance. Long service life.

5、耐磨性能、抗冲击性能、抗压性能极佳;

5. Good wear resistance, shock resistance and excellent compression performance;

缺点:

Disadvantages:

1、颜色选择有一定的局限性:常用的颜色只有水泥原色、灰色、绿色、红色等。

1. Color selection has certain limitations: the commonly used colors are cement primary colors, grey, green, red, etc.

2、某些低质量的彩色(如绿色)耐磨地坪,短时间内就会褪色。

2. Some low quality colored (such as green) wear-resistant floor will fade in a short time.

3、即使是彩色耐磨地坪,其颜色也做不到象环氧地坪那样纯正、饱和;

3. Even in the color wear-resisting floor, its color can not be as pure and saturated as epoxy floors.

4、抗渗透性较差:耐磨地坪其实就是一种高强度混凝土,它的抗渗透性能远不及环氧地坪,针对某些经常有油污存在的车间如机加工车间等,油污很容易渗入地坪内部,造成无法彻底清洁。

4 less resistance to permeability, wear-resisting flooring is actually a kind of high strength concrete, it is much less penetration resistance of epoxy floor paint, aiming at the existence of some often have oil such as machining workshop, the oil is easy to penetrate into ground level ground inside, cause cannot be cleaned completely.

5、不能抵抗化学药品的腐蚀:无机硅酸盐为主的化学成份,极易被酸、碱腐蚀。

5. Cannot resist the corrosion of chemical drugs: the chemical composition of inorganic silicate is easy to be corroded by acid and alkali.

6、表面光洁度远不及环氧地坪,尤其是质量较差的耐磨地坪可能还会起灰,因此不适用于对洁净度要求较高的地坪。

6. Surface finish is far less than the epoxy floor, especially the low-quality wear-resistant floor, which may also be graying, so it is not suitable for the higher floors.

适用范围:

耐磨地坪适用于需要承受车辆频繁行走、经常有重物撞击、经常有尖锐硬化磨擦、无腐蚀性化学药品存在、对洁净度要求不高、对美观度要求不高的各类工业、民用、商用地坪。

   Scope of application:

Wear-resisting flooring is suitable for the need to bear walking vehicle frequently, often have heavy impact, often there is a sharp hardening friction, no corrosive chemicals, the cleanliness requirements is not high, the aesthetic requirement of all kinds of industrial, civil and commercial floors.

共有:条评论信息评论信息
发表评论
姓 名:
验证码: